Page:Popular Science Monthly Volume 3.djvu/210

200 It is clear from these considerations, that, in order to insure the maximum effect from the fuel, the heating surface of the pipes should be sufficiently large to warm all the air required without its being necessary to raise the temperature of the water in the boiler to any great extent, and the proportion between the boiler-surface and the pipe-surface, that is to say, between the surface which absorbs heat, and the surface which gives out heat, should be such as to render it unnecessary for the fire to be forced, because, the lower the temperature at which the gases from the fire pass off up the chimney, the greater will be the economy.

In order to show the waste which results from forcing the boiler, i. e., from passing the gases into the flue at a high as compared with a low temperature, I will give an instance of one experiment. The proportion of heating surface in the boiler to the heating surface of the pipes is assumed by some manufacturers as 1 to 100, or, when great heat is required, 1 to 40. An experiment made on 4,000 feet of pipe, heating certain greenhouses by a wagon-shaped boiler with 40 square feet of heating surface, showed that a certain temperature was kept up for 8 hours with 8 bushels of coal; but when, by the addition of another boiler, the heating surface of the boiler was increased to 80 square feet, the temperature could be maintained for the same period with 4 bushels of coal. The outer temperature was the same on the two days.

On these grounds it is not so economical, so far as the consumption of fuel is concerned, to use steam instead of water, either water heated to a high temperature under pressure, or to heat air for warming purposes, because the gases from the fire employed to produce the higher degree of heat will pass off at a high temperature, and the heat they contain be wasted. On the other hand, the capital outlay required, where highly-heated pipes are used, is smaller than with hot-water pipes, because a smaller heating surface, and therefore smaller pipes, will suffice when the temperature is high; and, moreover, a very small pipe will convey steam to any required place, whereas with hot water, at a relatively low temperature, much larger pipes are required. It follows that where the price of fuel makes it necessary to reduce the permanent annual expenditure, the original capital outlay must be increased. There is a further consideration in regard to economy with hot-water pipes, steam-heating, and all appliances for warming buildings from a central fire, viz., that if the heat has to be conveyed for long distances before its useful application comes into force, very much heat is lost, and consequently fuel is wasted. On the other hand, against the saving which would result from a more immediate application of the heat to the place to be warmed, there is to be weighed the diminished expense of attendance consequent upon the use of one fire instead of several fires, each with its attendance and supply of fuel. There remains one source of economy to be applied to close grates used for heating water, which has not yet been adopted. I mean the