Page:Experimental researches in chemistry and.djvu/259

244 when it forms part of a combination consisting of two proportions silica, and one oxide of lead. As yet, the silica I have used has been the flint-glass-maker's sand, obtained from the coast of Norfolk, well washed and calcined. The silicate has been prepared by mixing two by weight of this sand with one of litharge, or with such quantity of nitrate of lead as is equivalent to one of litharge (16); the mixture is put into a large Hessian or Cornish crucible, which being covered over, has been put into a furnace and raised to a bright red heat for eighteen or twenty-four hours. On taking out the crucible, the charge has been found diminished somewhat in bulk, and of a porous structure and appearance like loaf-sugar. It has been freed from the crucible, the outside portions removed, and the pure parts carefully pulverized in a clean Wedgwood mortar. The powder has then been washed over in water, so as to obtain the whole in a fine state of division; after which it has been dried and preserved in bottles. No sieve should be used in these comminuting operations, nor any reducing or metallic matter brought in contact with the substance. Every care should be taken to avoid contamination. 24 parts by weight of the silicate are equivalent to 16 parts, or one proportional of silica, and 8 parts of protoxide of lead.

21. The advantage of the silica in this combined state depends upon the known composition of the substance, its comparatively easy pulverization, and ready fusion with the other materials. That there is iron in the silica (and the litharge when used) is objectionable; and the trials for its removal have only been delayed that the investigation of a more important point, namely, a successful process, might proceed. From some brief experiments, I am led to believe that an unexceptionable source of silica will be obtained by acting upon this silicate, in a state of fine division, by nitric acid and water, or else by the use of rock crystal.

22. On some occasions l used pulverized flint glass as the source of silica, conceiving that being already in a fusible state, it must possess an ad vantage over other silica, in allowing rapid mixture with the other materials. Allowance was made for the oxide of lead present, and the alkali was permitted to pass, as a substance that would probably do no harm. But a striking effect took place, which at once showed the necessity of