Page:Das Kapital (Moore, 1906).pdf/458

 One person there does the work formerly divided between two. In the weaving-room, where a vast number of persons are employed, and principally females the labour has increased within the last few years fully 10 per cent, owing to the increased speed of the machinery in spinning. In 1838, the number of hanks spun per week was 18,000, in 1843 it amounted to 21,000. In 1819 the number of picks in power loom-weaving per minute was 60—in 1842 it was 140, showing a vast increase of labour."

In the face of this remarkable intensity of labour which had already been reached in 1844 under the Twelve Hours' Act, there appeared to be a justification for the assertion made at that time by the English manufacturers, that any further progress in that direction was impossible, and therefore that every further reduction of the hours of labour meant a lessened production. The apparent correctness of their reasons will be best shown by the following contemporary statement by Leonard Horner, the factory inspector, their ever watchful censor.

"Now, as the quantity produced must, in the main, be regulated by the speed of the machinery, it must be the interest of the mill owner to drive it at the utmost rate of speed consistent with these following conditions, viz., the preservation of the machinery from too rapid deterioration; the preservation of the quality of the article manufactured; and the capability of the workman to follow the motion without a greater exertion than he can sustain for a constancy. One of the most important problems, therefore, which the owner of a factory has to solve is to find out the maximum speed at which he can run, with a due regard to the above conditions. It frequently happens that he finds he has gone too fast, that breakages and bad work more than counterbalance the increased speed, and that he is obliged to slacken his pace. I therefore concluded, that as an active and intelligent millowner would find out the safe maximum, it would not be possible to produce as much in eleven hours as in twelve. I further assumed that the operative paid by piece work, would exert himself to the utmost